2007 Ford Explorer Service and Repair Manual
Covers the 2007 Ford Explorer sport utility in three trims, with two engines from 4.0 to 4.6 litres: naturally aspirated V6 and naturally aspirated V8. Factory procedures, specifications and torque values for this model year.
NHTSA holds 208 owner complaints against the 2007 Explorer, most often about the powertrain (54).
Engines covered
- 4.0L V6 (245 cu in) — SOHC, naturally aspirated, gasoline
- 4.6L V8 (281 cu in) — SOHC, naturally aspirated, gasoline
Body styles covered
- 4-door sport utility
Trims covered
- Eddie Bauer
- Limited
- XLT
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR
When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-J
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
SOME 2007-2016 EDGE/MKX/FLEX/MKT/MKZ/MKS/TAURUS/TAURUS POLICE/EXPLORER/EXPLORER POLICE EQUIPPED WITH ALL WHEEL DRIVE (AWD) AND BUILT ON OR BEFORE 30-JUN-2016 MAY EXHIBIT A TICKING AND/OR KNOCKING NOISE COMING FROM THE DRIVELINE AREA. TO IDE
FORD/MERCURY: TO PREVENT HARNESS DAMAGE, ON SOME VEHICLES, RESULTING IN CONTACT WITH TIRE OR SUSPENSION COMPONENTS, PROPER ROUTING OF WIRING HARNESS FOR WHEEL SPEED SENSOR IS KEY. 2006-2010 EXPLORER, MOUNTAINEER, EXPLORER SPORT TRAC. *PE
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
FORD/MERCURY: SOME VEHICLES EQUIPPED WITH 6R60 TRANSMISSIONS MAY EXHIBIT VARIOUS TRANSMISSION PERFORMANCE ISSUES. WHEN COMPARED TO OTHER TRANSMISSIONS, SOME OF THE SHIFT CHARACTERISTICS ARE DIFFERENT THAN PREVIOUS MODELS DUE TO THE 100% SYN
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE
Showing the 8 most recent of 21 technical service bulletins on file with NHTSA.
The contact's brother-in-law owned a 2007 Ford Explorer. The contact stated that while her brother-in-law was driving 60-62 MPH, her husband was sitting in the front passenger's si
The contact's brother-in-law owned a 2007 Ford Explorer. The contact stated that while her brother-in-law was driving 60-62 MPH, her husband was sitting in the front passenger's si
Showing the 2 most serious of 208 complaints filed with NHTSA.
