1993 Hyundai Sonata Service and Repair Manual

WHILE DRIVING AT 10 MPH, MAKING A RIGHT HAND TURN, ANOTHER VEHICLE REAR ENDED CONSUMER'S VEHICLE, AND BOTH FRONT BACK SEATS BROKE. DRIVER WAS INJURED. MANUFACTURER CONTACTED, BUT PROVIDED NO HELP. *AK *ML

TRANSMISSION/RADIATOR/STARTER FAILED.

NO SUMMARY

BRAKE SYSTEM REPLACED AT PURCHASE BECAUSE OF SLOW REACTION AND NOISE, TRANSMISSION FAILURE ON HILL IN 5 O'CLOCK TRAFFIC, VALVE SEALS REPLACED AFTER CAR CONTINUALLY BLEW SMOKE FROM BURNING THE OIL, CATALYTIC CONVERTER REPLACED AFTER FAILING TO WORK, FRONT CAM, LIFTERS AND A ROCKER REPLACED (NO IDEA IF THIS COULD BE A SAFTEY HAZARD OR NOT BUT IT IS UNUSUAL), POWER STEERING PUMP REPLACED (MECHANIC SAID WAS IN POOR CONDITION AND WAS PITTED AND SUCH)CAR OVERHEATED SUDDENLY ONE DAY ON INTERSTATE-REPL

WHEN DRIVING THE VEHICLE THE ENGINE CHECK LIGHT KEEPS COMING ON. CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER, AND THEY CAN'T DETERMINE WHAT THE PROBLEM IS. *AK

HAVE REPLACED TRANSMISSION, FRONT CAM, LIFTERS, ROCKER, TIMING BELT, CATALYTIC CONVERTER, POWER STEERING PUMP, VALVE SEALS, WATER PUMP, THERMOSTAT, BRAKES. TO BE REPAIRED ENGINE-WISE: REAR CAM, DRIVE AXLES, CYLINDER HEADS OR HEAD GASKETS

POWER WINDOWS INOPERATIVE. *SD

STARTER FAILED. *SD

PROBLEMS WITH CHANGING GEARS. WOULD GO 30MPH. WOULD GET NO SPEED. TRANSMISSION MADE GRINDING NOISE. BEEN TO DEALER & HAD MECHANIC CHANGE TRANSMISSION. THE 2ND TRANSMISSION WAS SAME AS FIRST. TOOK VEHICLE BACK & TRANSMISSION REPLACED ONCE AGAIN, 3 MONTHS LATER, TRANSMISSION STOPPED WORKING. HAD VEHICLE TOWED HOME. FINALLY TOOK VEHICLE BACK TO DEALER & MECHANIC NOTICED THE MOTOR WAS DEFECTIVE. *AK

AT DIFFERENT TIMES AND SPEEDS, THE CAR WILL SKIP AT TIMES. SOME TIMES IT SURGES VERY BAD AND CHECK ENGINE LIGHT WILL COME ON. OTHER TIMES THE CAR WILL MISS AND THE CHECK ENGINE LIGHT DOES NOT COME ON. TECHNICANS AT DEALERSHIP CAN NOT FIND TROUBLE CODE FROM CHECK ENGINE LIGHT TO SOLVE PROBLEM. YOU MAY DRIVE 300 MILES WITH NO PROBLEM, AND THEN YOU MAY DRIVE 10 MILES AND IT SURGES AND THE CHECK ENGINE LIGHT COMES NUMEROUS TIMES. THE CAR HAS BEEN SERVICED, TUNED AND FILTERS CHANGED AND DOESN'T

TOOK THE AUTOMOBILE INTO DEALERSHIP TO HAVE A VEHICLE INSPECTION DONE. WHEN LEAVING DEALERSHIP NOTICED THAT THE DIRECTIONAL SIGNALS DID NOT WORK CIRCLED AROUND THE BLOCK AND DROVE THE CAR BACK TO THE DEALERSHIP. I EXPLAINED THAT THE DIRECTIONAL SIGNALS WERE WORKING FINE WHEN I BROUGHT THE VEHICLE IN. MR. RAY MARSHALL ACKNOWLEDGED THAT THE SIGNALS WERE WORKING WHEN THE VEHICLE WAS INSPECTED AND STATED THAT I COULD BRING THE AUTOMOBILE BACK ON TUESDAY 9/5/00.

TOOK THE AUTOMOBILE INTO DEALERSHIP TO HAVE A VEHICLE INSPECTION DONE. WHEN LEAVING DEALERSHIP NOTICED THAT THE DIRECTIONAL SIGNALS DID NOT WORK CIRCLED AROUND THE BLOCK AND DROVE THE CAR BACK TO THE DEALERSHIP. I EXPLAINED THAT THE DIRECTIONAL SIGNALS WERE WORKING FINE WHEN I BROUGHT THE VEHICLE IN. MR. RAY MARSHALL ACKNOWLEDGED THAT THE SIGNALS WERE WORKING WHEN THE VEHICLE WAS INSPECTED AND STATED THAT I COULD BRING THE AUTOMOBILE BACK ON TUESDAY 9/5/00.

FOREIGN MATERIAL STUCK IN RACK/PINION CONTROL VALVE ASSEMBLY CAUSED HIGH PITCH SQUEAL DURING RIGHT TURNS. *DH

STARTER FAILED CAUSING DRIVER TO KEEP TURNING IGNITION KEY OFF AND ON TO GET VEHICLE TO START. NLM

WHEN TURNING RIGHT WITH THE LIGHTS ON, THE SWITCH APPARENTLY SHORTS OUT ALL LIGHTS ON THE VEHICLE, INTERIOR AND EXTERIOR. HEADLIGHTS ARE EXTINGUISHED WHEN TURN SIGNAL IS APPLIED.