The 2006 Mercury Grand Marquis Service and Repair Manual is a practical, workshop-ready reference for maintenance, diagnostics, and repairs. Use it to troubleshoot symptoms, follow step-by-step procedures, verify specifications, and confirm wiring and connector locations before replacing parts.
Ideal for technicians and DIY owners, it supports everything from routine service to deeper mechanical and electrical work—including drivability, no-start, warning lights, overheating, brake and suspension issues, HVAC faults, and circuit testing.
Trims covered
- GS Sedan 4-Door
- LS Sedan 4-Door
Engines covered
- 4.6L 281Cu. In. V8 FLEX SOHC Naturally Aspirated
- 4.6L 281Cu. In. V8 GAS SOHC Naturally Aspirated
What’s inside
- Body
- Brakes
- Chassis Electrical
- Driveline
- Engine Cooling
- Engine Electrical
- Engine Mechanical
- Engine Performance & Emission Controls
- Fuel System
- General Information & Identification
- Heating, Ventilation, & Air Conditioning
- Hybrid & Electric Vehicle Systems
- Steering
- Suspension
- Transmission, Clutch, & Transfer Case
- Wiring Diagrams
Why this manual matters
- Faster diagnostics with system-based troubleshooting and wiring diagrams
- Clear procedures and reference sections to reduce guesswork and rework
- Helpful for maintenance planning and verifying parts/specs before repairs
Ford is recalling certain model year 2005-2011 Ford Crown Victoria (including Crown Victoria Police Interceptors), Mercury Grand Marquis, and Lincoln Town Car vehicles. The affected vehicles are curre
If the lower bearing separates, the vehicle may experience a loss of steering, increasing the risk o
Ford will notify owners and dealers will replace the lower intermediate shaft, free of charge. The
Inpected or repaired under 13R01 - Requests for recall service action under 13S08
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
FORD: THE LOWER INTERMEDIATE STEERING SHAFT, HAS CORROSION OF SWING LINK JOINTS, COMBINED WITH COLLAPSED UPPER INTERMEDIATE STEERING SHAFT, RESULTING IN STEERING COLUMN SEPARATION AND LOSS OF STEERING CONTROL. MODEL 2005-2011 CROWN VICTORIA
FORD/LINCOLN/MERCURY: IF BATTERY WAS DISCONNECTED OR DEAD, VEHICLES/TRUCKS MAY EXPERIENCE HARD STARTS AND ENGINE IDLE RPM FLUCTUATION AND EXHIBIT DIAGNOSTIC TROUBLE CODES (DTCS) P0505, P0506, P2111 AND P2112. *PE
FORD: ENGINE COOLING FAN CONTROL RELAY PART AVAILABILITY. *PE
FORD/MERCURY/LINCOLN: VEHICLES MAY EXHIBIT ONE OR MORE OF THE FOLLOWING SYMPTOMS: DRIVE AWAY HESITATION, LOSS OF RPM ON DECELERATION, DIFFICULTY STARTING, AND/OR IDLE RPM LESS THAN DESIRED. THE F53 MOTORHOME CHASSIS IS INCLUDED. *PE
SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE
ENGINE OVERHEATING-POOR A/C PERFORMANCE. *KB
Showing the 8 most recent of 16 technical service bulletins on file with NHTSA.
STOPPED AT RAILROAD CROSSING. TRAIN MOVING. 1 CAR AHEAD OF ME AT RAILROAD. STOP. I WAS COMPLETELY STOPPED. AFTER BEING STOPPED FOR ABOUT A MINUTE MY CAR SUDDENLY ACCELERATE AND SLAMMED INTO CAR IN FR
TL* THE CONTACT OWNS A 2006 MERCURY GRAND MARQUIS EQUIPPED WITH A MICHELIN P225/60PR16 DEFENDER TIRE. WHILE DRIVING 70 MPH, THE REAR PASSENGER TIRE BLEW. THE CONTACT STATED THAT THE VEHICLE CRASHED IN
MY 17 YEAR OLD SLID OFF ROAD IN SNOW STORM, HIT TREE HEAD ON, CENTER OF BUMPER CONTACT, BUMPER REINFORCEMENT BAR DRIVEN INTO RADIATOR, BOTH FRAME RAILS BENT, YET NO AIR BAG DEPLOYMENT TOOK PLACE.
TL* THE CONTACT OWNED A 2006 MERCURY GRAND MARQUIS. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE SUDDENLY ACCELERATED. THE REAR BRAKES LOCKED WHEN THE FAILURE OCCUR
TL* THE CONTACT OWNED A 2006 MERCURY GRAND MARQUIS. WHILE DRIVING AT AN UNKNOWN SPEED WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE SUDDENLY ACCELERATED. THE REAR BRAKES LOCKED WHEN THE FAILURE OCCUR
Showing the 5 most serious of 187 complaints filed with NHTSA.
