2012 Mazda 5 Service and Repair Manual

WE WERE REAR ENDED AND PUSHED INTO ANOTHER CAR IN FRONT, AND THE FRONT SEATS FAILED AND RECLINED WHEN WE WERE REAR ENDED. AIRBAGS DEPLOYED BUT DID NOT COME IN CONTACT WITH US SINCE WE WERE FORCED TO RECLINE. *TR

REAR-ENDED WHILE STOPPED BY TRUCK GOING UNDER 20 MPH. OUR HEADS STRUCK HEADRESTS AND DRIVER AND FRONT PASSENGER SEATS INSTANTLY RECLINED BACK ONTO FRONT OF CHILDREN'S CAR SEATS. THEY'RE LEGS WOULD HAVE BEEN CRUSHED AT THE KNEES IF THEY WERE IN THE ACCIDENT. OUR NECKS WERE SORE FROM WHIPLASH.

TL* THE CONTACT OWNED A 2012 MAZDA 5. WHILE MAKING A TURN AT APPROXIMATELY 53 MPH, THE CONTACT LOST CONTROL OF THE STEERING WHEEL. THE VEHICLE ROLLED OVER THREE TIMES AND CRASHED INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A CONCUSSION AND MINOR NECK, BACK, AND SHOULDER INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED AND DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,666.

Sentury Touring (Discount Tire) 205/55/R16. Both front tires have inner wear to the point of shredding in the same location on *both* front tires. Both tires went out at the same time and could have caused a serious accident. Discount tire stated it was an alignment issue. The alignment shop (30 minutes after new tires were installed after dual blowout) stated that my alignment was perfectly within spec and also stated there was no indication of tire rub on any portion of the vehicle.

The contact owns a 2012 Mazda MZ5. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed and went to the floorboard. The vehicle was taken to the dealer; however, the vehicle was not diagnosed nor repaired and remained at the dealer. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 118,000.

This vehicle ejects a significant amount of fuel from its fuel filler port during every refueling. The volume of fuel and the distance the gasoline travels in a hazardous environment poses an avoidable risk that can result in a catastrophic event with potential fatalities. In addition, the cumulative quantity of fuel needlessly spilled negatively impacts the environment at a time of heightened environmental concerns. For these reasons, this known issue should be elevated from a simple technical service bulletin (#01-013-15-3048) to a safety recall before fatalities result from a known manufa

During July of 2021 brake pedal went all the way down with no braking. Pumping the pedal restored braking. After the 3rd incident, had the master cylinder replaced on July 30, 2021 by certified mechanics. Brakes seemed fine, but on Aug 11, 2021 brake pedal went all the way down producing no braking on 3 occasions. Pumping the pedal restored braking. Took vehicle back to garage. Mechanics have not gotten it to fail. Possible new parts are bad? Could anti lock brake system cause this? Its been a really good car for 155,000 miles, but now I'm afraid to drive it.

The Mazda5 has a TSB on the issue, 01-013/15. What I am attempting to find out is why this isn't a recall. When the failure occurs, the fuelling of the vehicle doesn't shut off the nozzle. What happens is fuel comes spraying out of the opening, getting over the ground, the vehicle, and in most cases the person fueling the vehicle. My vehicle has been dong this almost since new. When I reported it early on, Mazda blamed the fuel pumps in my area. The next time I went in I presented the TSB but they still wanted me to pay for diagnostic procedures and even potentially for the repair. I